Driving My Car

[Mr_GaZZa]

Hey...

my car is nearly getting there.. after finding a VAC leak and replace 02 sensor and new fuel filter n pump.

it goes surggey,!!!

i've got some atmo BOV, and a GFB manual boost controller and a HKS Pod.

any ideas? i aint got much left to replace and rather spend it on BLING BLING then crap parts that dont fix it!!!

atm its running 13PSI

600 x 400 x 75 FMIC...

S/S 3" 1/2 inch turbo back WITH 7 " n 1/2 turbo box...

Forged pistons/rings/pins/shells/graphite gaskets etc...

cleaned/flowed/ported head with new stemseals/core plugs etc...

Stock ECU...

New Platium NGK Plugs 'yes pre gapped as per manual'...

GFB Manul boost controller...

HKS Replica SSQ BOV...

HKS Pod Filter...

Twin Plate Clutch...

HSD Coilovers

Yep thats it...

but i think maybe CAS... or BOV

any ideas please help... its lame, drives hell hard other wise

=S

Edited April 12, 2008 by Mr_GaZZa

[Adriano]

stock ecu...

ATMO BOV...

Got to wonder why spend all the $$$$$ on a built motor, then loose all the drivability and power with these two things?

[Simon-S14]

any ideas? i aint got much left to replace and rather spend it on BLING BLING

you got your priorities wrong buddy....

[lighty01]

wheres the boost controller??

is it near ur exhaust manifold?

that could be the prob? could be getting to hot (after 20 min)

i don't know.. im just throwing ideas

[Mr_GaZZa]

haha thanks lighty01... well could be, its hanging there LOL... maybe i should invest in a electric one?!

um i recently topped my batterie up with some distilled water, and put my stock BOV back on.

Doesnt have as much power... cause the stock BOv its leaking of the extra boost?

and also i got no 'PSTTT' noise going through the pod no more!? i use to ages ago....

any reasons why its not? i heard its called blowback... and its not good... correct?

well my problem i found that an intercooler pipe was blowen off... and leaking off boost... causing my other problem, along with a el cheapo BOV adaptor isn't 100% flat =/ i think thats it... not sure?!

else i might look at AFM or CAS timing...

[TTT]

extra boost?

how much extra?

you have an R33 with stock ecu and extra boost?

come on man....

[dnbutts]

if your loosing boost, check all your vacuum lines, cooler pipes and the BOV, if its a HKS replica its obviously cheap shit and quite possibly leaking boost.

get rid of the GFB boost controller and hook up your standard solenoid (if you have one) that should run 7psi on highboost and if it doesnt piss around and carry on then you know the valve is bollocksed (which wouldnt be hard do believe)

also, remember the standard ECU has a boost cut, if your running a squillion pounds on your standard tune the engine WILL stop it from boosting, mainly to protect the engine. ALSO! you have a standard AFR.

so your fuel/air ratios are not tuned and the more boost you run with a standard setting the more its not going to like it.

basically it could be anything. just have a look at all that.

[Mr_GaZZa]

but the factory BOV leaks of excess boost though!

my AFR are 11:## @ 13PSI, and yea it was at 1 BAR but i lowered it on the dyno lol to get higher HP.

and yes its a series 2 turbo

i am pretty sure thats save enough @ 11 ish air / fuel ratio!!

[TTT]

wether your turbo is safe at 13psi and 11.0:1 A:F ratio has nothing to do with the stock ECU going spastic due to AIR FLOW at that sort of boost at those revs.

just have a look at the thread titled "quiet screamer pipe".

the started "RB2530" has a few things to say about stock ecu and AFM cut etc.

Page 3 I think..

[Mr_GaZZa]

wether your turbo is safe at 13psi and 11.0:1 A:F ratio has nothing to do with the stock ECU going spastic due to AIR FLOW at that sort of boost at those revs.

just have a look at the thread titled "quiet screamer pipe".

the started "RB2530" has a few things to say about stock ecu and AFM cut etc.

Page 3 I think..

thanks mate i'll have a look s00n

[Mr_GaZZa]

ZOMG!

it was my stock boost controller...even though it was unplugged and return pipe was still connected it was taking in air from the top

nipple thing

OMG

and a tuner did it like that... fk me