What Have You Done To Your Stagea Lately?

[jasevr4]

Driving to work this morning, the heater isn't working. Just blowing cold air all morning. Temps were normal, didn't think too much about it. Just turned the climate control on and off a few times, didn't seem to do anything.

Then closer to work, temp is creeping up. Higher than normal but nothing ridiculous. Of course before long it's just below the H, I pull over and it's steaming.

Thing is, I reckon it's been cracked for a while. When I picked it up from the Toll depot there was a bit of coolant around the place, but the car never seemed to be complaining so I figured it was a previous coolant splash that had never been washed off. If this wasn't the case, then I've most likely been driving it around like normal, leaking the coolant slowly (the TransportSA inspection guys didn't say anything either), to the point where it's empty.

So yeah that's how my hour and a half commute to work was today. How hard is it to find radiators for these things?

[ironpaw]

Driving to work this morning, the heater isn't working. Just blowing cold air all morning. Temps were normal, didn't think too much about it. Just turned the climate control on and off a few times, didn't seem to do anything.

Then closer to work, temp is creeping up. Higher than normal but nothing ridiculous. Of course before long it's just below the H, I pull over and it's steaming.

Thing is, I reckon it's been cracked for a while. When I picked it up from the Toll depot there was a bit of coolant around the place, but the car never seemed to be complaining so I figured it was a previous coolant splash that had never been washed off. If this wasn't the case, then I've most likely been driving it around like normal, leaking the coolant slowly (the TransportSA inspection guys didn't say anything either), to the point where it's empty.

So yeah that's how my hour and a half commute to work was today. How hard is it to find radiators for these things?

Sorry to hear that. Seems like the previous owner hid the issue pretty well...or did the issue not manifest it self till now?

[jasevr4]

Sorry to hear that. Seems like the previous owner hid the issue pretty well...or did the issue not manifest it self till now?

Don't want to think the worst of people... who knows..?

[jasevr4]

Do v35 radiators fit?

[Ross]

i replaced my rad a few months back.

I got a new replacemnt unit from natrad, was around $650 not installed. At the time he said there was 2 left in oz on there stock list.

[jasevr4]

That was a m35 one yeah? Anyone know if v35 and m35 are identical?

[Ross]

It was a M35 rad.

The part numbers for v35 rads are different so they may not be the same.

[bigkevracer]

I thought the V35 auto ones were?

Buy Ironpaws. His wife will kill him and scrap his car shortly!

[scotty nm35]

Are you sure the radiator is cracked? The water only has to be half a litre short to show these kind of overheating issues, even 200ml will cause problems.

[Sunkist]

they arent the same, but do fit with the tiniest of modding.

just make sure you find an auto one, as you'll need the trans cooler in there too

[ironpaw]

I thought the V35 auto ones were?

Buy Ironpaws. His wife will kill him and scrap his car shortly!

LOLLLLL

[Dunc]

That was a m35 one yeah? Anyone know if v35 and m35 are identical?

Brad, ducati02 on here, did his radiator late last year - brief summary of it http://www.m35stagea.info/forum/viewtopic.php?f=2&t=114&p=1048

[jasevr4]

Are you sure the radiator is cracked? The water only has to be half a litre short to show these kind of overheating issues, even 200ml will cause problems.

Can't say I'm 100% sure. Any way to test without one of those pressure things?

[Jetwreck]

Just so you know the V35 manual one fit's in with a little bit of cutting......I had one in mine....I lent it to someone about 6 months ago for a couple of weeks.

When I do get it back it will be for sale.

[scotty nm35]

Can't say I'm 100% sure. Any way to test without one of those pressure things?

Usually the Oring goes on the top tank. It may hold pressure fine until its hot. These can be replaced.

I would just fill the system from the rear bleeder, behind the drivers side head, and check it a few times to make sure its full. If it still leaks there is a problem.

The coolant can spurt out the top of the overflow container if it gets full which could be your spray in the engine bay.

[MOUTH]

Driving to work this morning, the heater isn't working. Just blowing cold air all morning. Temps were normal, didn't think too much about it. Just turned the climate control on and off a few times, didn't seem to do anything.

Then closer to work, temp is creeping up. Higher than normal but nothing ridiculous. Of course before long it's just below the H, I pull over and it's steaming.

Thing is, I reckon it's been cracked for a while. When I picked it up from the Toll depot there was a bit of coolant around the place, but the car never seemed to be complaining so I figured it was a previous coolant splash that had never been washed off. If this wasn't the case, then I've most likely been driving it around like normal, leaking the coolant slowly (the TransportSA inspection guys didn't say anything either), to the point where it's empty.

So yeah that's how my hour and a half commute to work was today. How hard is it to find radiators for these things?

They also had to fit a radiator to mine prior to compliance as it had a split tank, so it must be common?

[jasevr4]

Usually the Oring goes on the top tank. It may hold pressure fine until its hot. These can be replaced.

I would just fill the system from the rear bleeder, behind the drivers side head, and check it a few times to make sure its full. If it still leaks there is a problem.

The coolant can spurt out the top of the overflow container if it gets full which could be your spray in the engine bay.

You reckon fill it up and give it a few more days to see how it goes?

Where is this Oring? I need to get FAST sorted out so I can look at the diagrams...

[scotty nm35]

You reckon fill it up and give it a few more days to see how it goes?

Where is this Oring? I need to get FAST sorted out so I can look at the diagrams...

Yep, I have had the overheating thing so many times, I just fill at the rear bleed and it goes away. That said, if it is leaking you should keep a few litres of water in the back just in case.

[scotty nm35]

They also had to fit a radiator to mine prior to compliance as it had a split tank, so it must be common?

If the top tank is cracked you will definitely know about it. The Oring seals the whole underside of the top tank and usually only weeps when warm, sometimes it sprays out from one side.

[Dunc]

Where is this Oring? I need to get FAST sorted out so I can look at the diagrams...

Clicky Ctrl+F "Radiator"