Jump to content
SAU Community

Recommended Posts

Just want to know if any one had done a how to vid or a step by step write up on how to rebuild callipers?

I'm needing to rebuild one set of fronts and 2 sets of rears for use on my AE86 and don't feel like parting with the extra $300 in labour when I could prob do it myself given the instructions.

Can anyone help?

Link to comment
https://www.sau.com.au/forums/topic/362937-how-to-rebuild-r33-gtst-callipers/
Share on other sites

Mate it's fairly simple. I rebuilt a pair of fronts for my S13. Ordered the rubbers kit online, and stuck it all in between the two freshly-painted halves. Just remember how you take it apart, and take care not to damage your o-rings or scuff/scratch your pistons.

Google "nissan skyline engine manual" some where in all the clutter is a full service manual, I think its on a UK site, its to big to email or post and I CNBF looking for it myself.

you don't need to pull the caliper apart to do new seals

you just have to get the boots off each pistons which is held on by a metal o-ring then get a screw driver pry out the pistons or compressed air to push them out

then just get the rubbers out that sit in the grooves around the pistons and replace them with the new ones and pop them back in

then put new boots and o-rings back on

a rebuild kit from nissan should have new boots for the pistons and the metal o-rings that hold them on as well as the rubber rings that sit inside the slot on the piston

the hardest part that will rage you and possibly take skin off your(my) knuckles is getting the pistons out if you don't have compressed air, if you're using a screw driver to pry them out be mindful to stick a rag or something inside an exposed cylinder near it that you could slip and ram your screw driver into and scratch the side

also if you're doing the screw driver method you have to be patient and pry from a couple of different points around the cylinder to get an even lift or they just jam and you find yourself going no where

Where did you get the rebuild kit? also where can i get the tightening torques for when i stick the 2 halves back together? i watched a few youtube vids and it seems easy enough...just keep it all clean and i should be good....

Mystery, most kits come with the little 8 or 10mm o-rings to put in the gallery joins between the two halves. So if you get a kit that has them, you should pull em apart - 100% fresh!

With regard to torqueing them up, I just tightened until it 'felt right' haha. No dramas. But if you want, check that workshop manual stated above. They'll be in there.

I got my kits off of a seller on nissansilvia.com, I'll dig him up when I get home to my PC for you.

Edited by fastjetjockey

Yeh I found a trick with these is use a bunch of mdf strips and try and keep them centred then blow the things out a lil, remove a strip, blow a lil more, repeat till on pops out then the others will also almost be out.

You don't need compressed air just take out the pads and depress brake pedal. You can put progressively thinner bits of wood bits of wood in where the pads were if you are worried or have some one watch the pistons as you do it. . A tip: do one side at a time so if you forget how it is supposed to go together you can look at the other side.

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • One other question, is there a chance that changing the idle speed can lead you down a rabbit hole and is the reason the tuner didn't touch it? Reason I ask is because if that's the reason the tuner avoided it then I probably shouldn't be touching it lol.
    • Pfft. As if I'd ever point a high pressure washer at my car.
    • The nature of my commute has changed. Way back then it was traffic lights all the way, for ~28km. It sucked. When they finally stitched the expressway together I could do a good 15+km of it at a steady 80-100 with no stopping. That alone has gotten me down to flat 10s. Prior to that it was mid-high 10s. I can't remember the delta that I saw when I got the idle down. It was only ~150 rpm, because the idle speed was never terrible, but for the delta in consumption to be noticeable it would have had to have been at least 0.2-0.3 L/100km - which is not to be sneezed at when it comes for absolute free. It's only about 50L per year, but that's ~$100. A few extra pizzas is always welcome. Note that I have a record of every tank of fuel that has ever gone through my car except for a handful put in by someone else, like my mechanic. I can show you the difference between stock RB20 and tuned RB20, stock RB5Neo and tuned, winter and summer fuel blends, winter and summer fuel blends when the ambient temperature is not appropriate for the blend, working O2 sensor, blown O2 sensor, boosting f**k out of it and frightened to boost it because it is pinging, and so on. OK, I probably can't do all that now with 100% clarity - but at the time when any of those things were in event, you could see it in the records. There's 25+ years of simple tank after tank records, so you have to look for landmarks to work out approximately how old any single record is. What's really important is the meta data and that lives in my head.
    • If you're claiming the issues are not skyline specific, then either the USA is living in the 90s / early 2000s, OR you have the issue of "survivor bias". Which is you're mainly hearing and listening to those with terrible experiences, and haven't found the guys who have cars with good decent builds and no problems. It happens in AU too, that plenty of people keep having issues, and they keep going to the workshops that are known to be shit "because I read on the internet". Even worse, are those who keep posting on the internet as though they know for a fact what something is, when they've never touched/looked at said item in their life, and again are making assumptions, based on something they read, or because it's a certain way in other cars. It's even funnier when those same people debate the facts with the people who've lived and breathed this stuff for over 15 years. Example, I've had someone tell me you can't do something with a Skyline, because they read it on the internet, except I can tell they're wrong, as I did that exact thing back in 2008 with my Skyline.
    • The funniest part I saw, was someone would bitch and moan on FB about something, Andy would be the one to respond, asking for more info, if he could contact them, what the engine setup is, what their config file was, and 95% of the responses were people just going "der! It doesn't work" and Andy going "What doesn't work?" And then going "The firmware!" And they'd go around in circles as no one could ever give information, and Haltech couldn't fault things on the bench, (especially when people wouldn't give any specifics).   Many moons ago, when Andy was back at e420c stage, he reached out to me, and asked me to test different plug and play looms for him (already had an e420c in the car on his V1 PNP loom). And he kept asking me, as I was competent enough to be able to give him some specific feedback on what was/wasn't working, how to replicate the faults etc, and work through things with him. Most people are terrible at answering the questions they're asked, or being able to provide quality feedback other than "it doesn't work".
×
×
  • Create New...