Jump to content
SAU Community

Recommended Posts

Ok, I've been waiting for my engine to rack up 1000ks to make sure nothing goes bang.

I bought parts through a friend of a friend, and he supplied mahle forged pistons.

He also neglected to inform me that they foul the oil squirters.

So, after the first piston was in, went to turn the crank over, and it got real hard.

From here, I checked to see what was happening....

What i found was the piston fouling the squirter.

So? What do i so now?

Answer: mod the squirters to fit.

I have attached(hopefully) pics of the modded squirters, with pics of installed so you can see where they foul, and how little room you will have.

Ok, first things first:

post-37584-0-94172700-1326715016_thumb.jpg

You will have to grind the locator flat.

I used a bench grinder.

CAUTION: being a small amour of alloy, it gets very hot, very quick.

Second:

post-37584-0-39635600-1326713647_thumb.jpg

Grind the back edge of the squirter at an angle.

Third:

post-37584-0-62394600-1326713902_thumb.jpg

As you can see her, I have used a copper washer.

The piston comes down to the point where it nearly contacts.

My thoughts were, I don't want to risk inertia just bringing them into actual contact.

Better safe than sorry.

Fourth:

post-37584-0-60415400-1326713755_thumb.jpg

post-37584-0-49816100-1326713828_thumb.jpg

As you can see here, positioning of the squirter is critical!

Too far one way, it will hit the under piston bracing.

Too far the other, it will foul the rod.

You can see where the locator would have gone.

To torque without the squirters moving, I used a pair of long nosed pliers in the locating hole.

And done them up to the highest point of factory torque specs.

I can't remember, but I think I also used a drop of loctite.

So, there you have it.

As stated, have been running my engine for 1000kms now, without incident(touch wood).

I've also had my engine spinning at/near redline.

Any questions, pm me.

Hope this helps others, as I couldn't find much on it other than people saying, "yeah, I've heard they foul."

Cheers, happy modding....

Link to comment
https://www.sau.com.au/forums/topic/388472-rb26-oil-squirter-mods/
Share on other sites

I'm guessing loss of oil pressure.

And i was building in my garage, don't really have the equipment needed to notch a piston.

Don't really know, but some may, would notching the piston weaken it?

Thinking about it, I think it would.

But thanks door the comment.

I appreciate feedback, and other ideas.

the piston wouldnt really vibrate if one side was notched as it is reciprocating (up and down) only, if it was rotating then it might make a difference

weight matching to the lightest over all weight is all that is really needed

if you do notch the pistons then dont forget to debur them

though i more think that getting the right pistons is the right way to do things from the start, if not then this way should be plan b

hey luke do you know if it alters the angle or the spot the oil squirt hits?

the piston wouldnt really vibrate if one side was notched as it is reciprocating (up and down) only, if it was rotating then it might make a difference

weight matching to the lightest over all weight is all that is really needed

if you do notch the pistons then dont forget to debur them

though i more think that getting the right pistons is the right way to do things from the start, if not then this way should be plan b

hey luke do you know if it alters the angle or the spot the oil squirt hits?

Ok, keep in mind the following are only MY thoughts and opinions, and this is the first motor I have rebuilt....

In regards to the balance of the piston,,,,

If you were to take material from one side and not the other, this would cause an off balance, and would make the piston want to "tilt", under the stress of high rpm, causing the difference in weight to multiply, I would think the piston would want to tilt more and more, like a see-saw out of balance.

This would in turn, cause higher wear rate on the edges that the piston wants to tip to.

In regards to the oil angle and hit zone,,,,,

No, it does not alter the angle the oil will hit at, as all the mounting surfaces are parallel, and the squirter is not bent.

The hit zone is a different story.

As the squiter has been twisted, it will now hit a different part of the piston, but keep in mind, they are different pistons being used.

The oil still hits the bottom of the piston, as intended, just in a slightly different place.

Hope this helps.

Again, my views and opinions, others may vary.

I appreciate the feedback and interest though guys.

Wouldn't putting a thicker copper washer under the squirter been an easier fix?

If you see the pics, that's what i done, as well as repositioning them.

The washer would have to be approximately 5-8mm thick, and the factory banjo bolts arnt long enough to allow this.

Space it out too far, and it will also foul the counter weights on the crank.

lucky my pistons (CP) came with the cutouts for the squirters :D cant u just cut the pistons section out and get them re balanced ? i wouldent alter the position of the standard squirter because if Nissan engineered it that way its for a damn good reason right ?

<br />But you got a perfectly balanced piece of metal sitting on a pivot going up and down. I know there isn't much room in the bore for movement, but i'm probably talking about stuff I don't know lol.<br />
<br /><br /><br />

If that were a real issue, then all the pistons that have the gudgeon pin offset to one side would have problems. And they don't.

  • 1 year later...

hi i'm going to be fitting 87mm mahle pistons to my own block - i just wanted to ask how your car is running now after 1000km and i'm guessing a remap too?

just wondering as this seems to make sense but wanted to see if theres been any issues? I cant see how personally.. I read a 2.5mm washer is enough to 'lift' the oil jet (squirter?) so it clears the piston skirt?

ta

ant

hey maye.

ran fine for about 2500kms.

then I was limiter bashing on a skid pan, and bearings let go.

the squirters are still fine, and in position.

in relation to the extra thick washer, from memory, 2.5mm may have been enough, but it would squirt directly onto the bracing, not under the piston head which is where its meant to go.

either way, good luck.

If you see the pics, that's what i done, as well as repositioning them.

The washer would have to be approximately 5-8mm thick, and the factory banjo bolts arnt long enough to allow this.

Space it out too far, and it will also foul the counter weights on the crank.

also, see this post, just above.

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • Update: I got the magnet out. I bought 3 different flexible magnetic reach tools, but none of them worked. The magnet on the tip was all less than 2lbs of force, so i had to buy a special cylindrical magnet that had a pull force of 9lbs.  The magnet finally came in the mail yesterday, so i got under the car to get to work. The super strong magnet isn't that long, so i only have about 1 finger pinch lengths to hold it. I was so scared when i was going in the hole, that the 9lb magnet would just fly away inside the oil pan never to be seen again, but i had my butt cheeks clenched and finger gripped on that thing so tight, i managed to get it to suck the other magnet out.  It was a victory for me last night.         
    • Yep, pretty much what you said is a good summary. The aftermarket thing just attached to the rim, then has two lines out to valve stems, one to inner wheel, one to outer wheel. Some of the systems even start to air up as you head towards highway speed. IE, you're in the logging tracks, then as speeds increase it knows you're on tarmac and airs up so the driver doesn't even have to remember. I bet the ones that need driver intervention to air up end up seeing a lot more tyre wear from "forest pressures" in use on the highway!
    • Yes, but you need to do these type certifications for tuning parts. That is the absurd part here. Meaning tuning parts are very costly (generally speaking) as well as the technical test documentation for say a turbo swap with more power. It just makes modifying everything crazy expensive and complicated. That bracket has been lost in translation many years ago I assume, it was not there.
    • Hahaha, yeah.... not what you'd call a tamper-proof design.... but yes, with the truck setup, the lines are always connected, but typically they sit just inside the plane of the rear metal mudguards, so if you clear the guards you clear the lines as well. Not rogue 4WD tracks with tree branches and bushes everywhere, ready to hook-up an air hose. You can do it externally like a mod, but dedicated setups air-pressurize the undriven hubs, and on driven axles you can do the same thing, or pressurize the axles (lots of designs out there for this idea)... https://www.trtaustralia.com.au/traction-air-cti-system/  for example.... ..the trouble I've got here... wrt the bimmer ad... is the last bit...they don't want to show it spinning, do they.... give all the illusion that things are moving...but no...and what the hell tyre profile is that?...25??? ...far kernel, rims would be dead inside 10klms on most roads around here.... 😃
    • You're just describing how type certification works. Personally I would be shocked to discover that catalytic converter is not in the stock mounting position. Is there a bracket on the transfer case holding the catalytic converter and front pipe together? If so, it should be in stock position. 
×
×
  • Create New...