Jump to content
SAU Community

Overheating?

f3lix

By f3lix,
in General Maintenance

 Share

Recommended Posts

f3lix Explorer

f3lix

Posted
Posted

Hey guys..

havent had this car for long and only noticed that, once warmed up, the needle is 'sitting' on 2/3 up towards H!

I must of did a 2 hr drive back home when i first realised and seemed fine.. continues to be fine now

the car is completely standard bar frount mount and exhaust

I've already drained old coolant and refilled with new, checked and replaced radiator cap and thermostat.

im not sure what else i may be able to do?

been searching around i cant seem to find anything about it?

Link to comment
https://www.sau.com.au/forums/topic/389071-overheating/
Share on other sites
cobbadan Enthusiast

cobbadan

Posted
Posted

If its overheating while driving ie: sitting on the highway at 100 --- I would be checking the radiator for blockages.

best way to do this (as far as i know) is to remove the radiator, boil the kettle, rad cap on , lay it down flat and poor the boiling water into it.

When its full, place your hand on the fins and move it all around feeling for areas that are cold.

When i did this with mine it was really easy to pick up,, i had a large area that was blocked.

If its overheating when sitting in traffic jams, then look at your viscous fan clutch.

google has plenty of advice about how it should operate and how to test it.

Link to comment
https://www.sau.com.au/forums/topic/389071-overheating/#findComment-6201290
Share on other sites
gotRICE? Veteran

gotRICE?

Posted
Posted

So your saying that it gave you the same reading after you changed the thermostat, did a flush, new coolant and thermostat?

If it did, then as mentioned it can only be one of two things, dodgy temp sensor or blocked radiator.

Link to comment
https://www.sau.com.au/forums/topic/389071-overheating/#findComment-6201426
Share on other sites
Kinks Grand Master

Kinks

Posted
Posted

Yes use a consult cable ASAP. Assuming the stock gauge is correct, any movement upwards means your temp must be at least 110C and you're about to cook your motor. I've had my temp (reported by consult) as high as 104C and the gauge still said halfway.

Link to comment
https://www.sau.com.au/forums/topic/389071-overheating/#findComment-6205449
Share on other sites
f3lix Explorer

f3lix

Posted
  • Author
Posted

After it's been warmed up, whether i'd be sitting in traffic or on highways at 110, the gauge would read the same or close enough.

After all the above where changed and replaced it remains the same. It did however go very close to the line below H after a long drive from City to Penrith and back last night but dropped shortly after, while still travelling at the same speed :/ ?

I havent had the chance yet to try the temp sensor and radiator but will do this weekend if possible. I dont have a consult cable so i might just take it down to the mechanic to check this asap.

Cheers for the info guys i'll provide an update

Link to comment
https://www.sau.com.au/forums/topic/389071-overheating/#findComment-6205991
Share on other sites
f3lix Explorer

f3lix

Posted
  • Author
Posted

so i haven't yet been able to take it to the workshop to get it checked out as yet due to work and other commitments...

i did just come back from the garage after having another quick look at the car again.. had a quick look at the radiator and the core is only 15mm give or take!!!!??

i dont know how i missed it before but just checked the part number on the top tank... PAT-APP-48-86457.. quick research reveals possible DE radiator or some sort :/

does anyone have the part number of their OEM radiator to confirm?

I think a new radiator is definitely a must!

Link to comment
https://www.sau.com.au/forums/topic/389071-overheating/#findComment-6214553
Share on other sites
GTRPSI Mentor

GTRPSI

Posted
Posted (edited)

Clogged radiator, or fins on the water pump after that, more than likely a clogged radiator

As mentioned could be a faulty temp sender too, you never know....

Edited by GTRPSI
Link to comment
https://www.sau.com.au/forums/topic/389071-overheating/#findComment-6214685
Share on other sites
  • 2 weeks later...
f3lix Explorer

f3lix

Posted
  • Author
Posted

I went ahead and just got a new all alloy radiator and silicone hoses. Got everything fitted fine. The workshop took it for a spin to get it up to temp and apparently thermostat wasnt opening!

Top hose was boiling and bottom hose was very cool.

After changing almost everything in the whole cooling system it ended up being a dodgy waterpump :(

Well at least the problem is now gone!

Link to comment
https://www.sau.com.au/forums/topic/389071-overheating/#findComment-6234006
Share on other sites
TTT Grand Master

TTT

Posted
Posted

did you do a timing belt kit when you did the water pump?

At least you know now that you won' thave any overheating problems.

FYI - 3/4 on the temp gauge is about 105 degrees according to my ecudatascan device which connects to the consult port.

From there it gets to 115 really quickly.

May have cost you a bit of money but at least you are not up for a broken motor.

here are a list of things ot try in order of cost (cheapest to most expensive) for others who may eventually come here and search for "overheating" "radiator" etc

Radiator cap - New from nissan - part number available in forums

New coolant (personaly I'd dump coolant, hose out radiator, fill with demineralised water and bleed off and drive for 30-40 minutes and repeat 3 times - letting it cool in between obviously)

new thermostat - New from Nissan - part number available in forums

now starts to get expensive....

New radiator or get your one cleaned by a radiator shop (keep in mind that if you get a new Thicker radiator, you may have issues with the factory Viscous clutch fan touching or the shroud not fitting - Shroud is VERY important to have on the radiator for the fan to work to full effect.)

New viscous clutch for the fan

New Water pump (might as well do the timing belt and make it a proper 100K service)

My suggestion is to NOT use a radiator flush kit that you can buy from supercheap etc - By doing so, mine got blocked more

I'd also replace the top and bottom radiator hose if replacing the radiator.

Link to comment
https://www.sau.com.au/forums/topic/389071-overheating/#findComment-6234094
Share on other sites

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now
 Share
Go to topic listing


  • Similar Content

  • Latest Posts

    • MBS206
      New fix for low tyre pressure from bmw

      By MBS206 · Posted

      I believe Unimog is the only vehicle that has it (from the manufacturer). I haven't seen aftermarket permanently connected kits, but I haven't looked either.
    • MBS206
      The Ls1 R33 Of Fury

      By MBS206 · Posted

      Ha ha ha, can't overthink when exhausted... Oh how I wish I had that power! I can be absolutely dead set shot, and my brain will still go "we need a good 3 or 4 hours to just think about everything and anything before you may sleep... My biggest thing is making sure I give myself enough sleep. I don't operate on even 7 hours of sleep! I attempt to give my body 9.5hours sleep a night to be able to function. I don't sleep the whole 9.5, but I need to make sure I offer a big window. I also take a single supplement, which is to help with long term health, and fighting inflammation, and I notice it helps massively. Especially me sleeping, and just less "achey" in the body. Have also kicked sugar, and gluten. A majority of people with ADHD don't go well with gluten. It causes a really interesting natural opioid overdose in the brain, which causes bodily issues and sensory issues.
    • Duncan
      New fix for low tyre pressure from bmw

      By Duncan · Posted

      Yeah that's what I meant, permanently connected not manual
    • MBS206
      New fix for low tyre pressure from bmw

      By MBS206 · Posted

      Yep. But typically that's just run a hose down to the tyre while stationary.   Oh and the Unimog will automatically air up and air down tyres from the onboard computer for you too.
    • Kinkstaah
      The Ls1 R33 Of Fury

      By Kinkstaah · Posted

      There was a good video somewhere, maybe Kurzgesagt that linked physical activity to ADHD/Anxiety/Insomnia etc. Basically the body WILL spend energy doing something if you don't spend it doing anything physical. It isn't fun, but I personally have noticed I've never been overthinky, or unable to sleep if I'm physically exhausted from doing a lot. The musings around it seem to indicate that this is one of the reasons/mechanism that physical activity improves mental health/wellbeing etc, by more or less not using that 'extra' energy to overthink, be anxious, inflammation, etc. There's also the fact that every obnoxious exerciser ever says it's great and helps which is extremely annoying. Like people who say the same thing about travel being the best thing ever. I mean, they clearly are, but blah. I started doing a LITTLE myself (think 3x15min per week) and honestly did notice the benefits, aiming at life quality when older. Which is sooner than you think. Getting something into your routine that you can actually make a routine has helped me at least. This post brought to you by procrastination between sets.
×
×
  • Create New...