Jump to content
SAU Community

Recommended Posts

An interesting build which we have been commissioned for. Take 1 x well used, 70,000km 09 ADM GTR and build it into a reliable daily driveable and mid 9 second package. First up to strip the car....

intbil1.jpg

Dropping both engine and transmission out of the vehicle its time to start stripping them down and begin the process of making something ultimately more power and much stronger. Already this GTR with a small turbo upgrade on 98 octane fuel put down 385kw at the rear wheels

intbil2.jpg

The stock engine although have a few kms under its belt was near perfect internally, with not a mark on the bores...which kind of makes the whole 80,000km rebuild thing look like the internet myth that it really was. This old girl looked like she could have gone another 100,000km without batting an eyelid

intbil3.jpg

The new powerplant is a Greddy 3.8 litre combination we have put together with forged pistons/rods, head studs, and HKS head gaskets. This engine should have no trouble supporting 25 - 30 psi of boost pressure reliably - should it be required.

intbil4.jpg

On top of the tough bottom end we are putting a set of Stage I cylinder heads, lightly ported, cleaned, and freshed in line with the rest of the engine.

Next we will finish the engine and build a tough and reliable transmission to hold the 550+rwkw this combination needs to put down :)

  • Replies 57
  • Created
  • Last Reply

Top Posters In This Topic

intbil455.jpg

Engine was buttoned up today and most of the ancillaries put back onto it getting ready for installation back into the subframe. At the moment we are also rebuilding the bell housing to remove that annoying rattle many GTRs suffer from and toughen up the installation some. Everything is on track in this department - and notice the extended sump - important for high horsepower GTRs that may just well see a track.

intbil5.jpg

With the engine being finalised its time to lay out the newest generation GReddy twin turbo kit featuring the cast manifolds to avoid any chance of cracking under high engine loads. It looks like a nice setup, but having a fair bit of experience with the GReddy kit we are making some of our own little engineering changes to make it even better!

intbil6.jpg

The transmission had covered 70,000km and to the best of my knowledge had been on factory fluid all its life. While the gearset was in ok condition the selector pistons were rounded and worn which meaned we had to use our new WR35PC (Piston Clip) to ensure that these didnt turn and cause errors during operation. This is one of the reasons that the transmission was in fault mode when the vehicle was shipped to us (not a local Aussie car). Here is a picture of our fix -

wr35pc1.jpg

This is very similar to the 'Nissan TSB caps' used when these transmissions wear prematurely under warranty. Note the transmission in the picture isnt the transmission out of the car, its a dummy up for the sake of the photo

Another part of the build we have undertaken for this car is the complete overhaul of the troublesome and noisy factory Nissan Bellhousing assembly. We modified it complete to make it fully floating so that it could never give any drama in the life of the car from here on in. Replaced the bearings, clips, sleeved it etc. It will be and remain to be totally silent now :)

int35bila.jpg

If this kind of repair work isnt undertaken whilst the engine is out the bearings and crankshaft can be damaged long term.

good to see we have a local source for transmission/drivetrain repairs - i think most aussies are still adverse to mod'ing due to the stigma of the first US gearbox issues

ive read about the bell housing tsb in US, what exactly are the symptoms or noises to look out for?

Edited by domino_z

Got on track today with the installation of the GReddy turbocharger system on the GTR engine. This is a very neat install due to the kit being JDM and therefore engineered around RHD cars where most of the American product uses LHD as a base and generally runs smack/bang into the steering column of Aussie cars. Dont ask us how we know this! (much hair missing)

intbilb.jpg

Greddy TD06 turbochargers using the latest generation cast iron manifolds. If you are putting turbos on your R35 then ensure you have cast manifolds....as getting at them if something goes wrong is an engine out job and takes a little time

intbilc.jpg

Large 20G turbine wheels should flow enough air to see north of 550awkw without overly stressing the engine

intbild.jpg

Twin external wastegates mounted nice and tight to the bellhousing will keep the backpressure in the manifold down and the power up! :)

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now



  • Similar Content

  • Latest Posts

    • So stock ECU does not like anything above 10 psi?  That Nistune one is just for "try" if it will be any different, I know it need to be tune for that. I know but YOU may know about these problem but i/we dont. They few little Skylines here let alone people who know anything about tham so that is why iam asking here  
    • So now we have a radiator with no attachments whatsoever. It lifts up with a particularly tight spot between the drivers side air box mount and the lower radiator outlet, but if you've got this far you will sort that too. This is the lower mounts with the rad out so you can see where the rubber bushes go, it is a straight shot upwards Done! Assembly is the reverse of disassembly, with blood less likely to be shed.
    • Right, onto the second last trick. The Air Con condenser is mounted to the front of the radiator and stays in the car when the radiator is removed. There are 2x 10mm headed self tappers holding the top of the condenser to the radiator, remove those The bottom of the condenser is attached to the radiator with clips. You need to lift the condenser out of those clips and clear (up, then forward). f**ked if  could work out how to do that last bit with the front bumper on. I hope you can, and you share the trick.  Bumper removal probably deserves its own thread one day once I've recovered the will to live, but basically you need to remove the wheels, front inner guard liners (clips and 10mm headed bolts), the self tapper between the guard and the bumper at the rearmost point of the bumper (same as an R32 that bit), any remaining clips at the top/front of the grill, an absolute bastard design with a plate that holds the top of the bumper above the headlight each side (only 1 bolt which is tricky to get to, but the plate catches 2 places on the bumper and must be removed....carefully!) and push clips between the bumper and guard under the headlight. If you've done all that you will be faced with wiring for the fog lights on both sides and in ADM Q50 RS at least, 4 nasty tight plugs on the driver's side for the ADAS stuff. So, the clips at the bottom look like this on drivers side (looking from the front) And on the passenger side (also from the front), you can see this one is already out Clearance on both of these are super tight; the condenser needs to move up but the upper rad support mount prevents that, and the radiator can't move down far because it is (rubber) mounted. Once you achieve the impossible and drop the condenser off those mounts so it does not stop the rad moving, you are good to go
    • OK, next the shroud needs to come off and there are a couple of tricks. Firstly, there is a loom from near the passenger side headlight to the fans, coolant temp sensor etc and there is no plug to undo.  In my case I was OK to leave the shroud on top of the engine so I just undid the passenger side fan plug and about 10 of the clips which gave enough free wire to put it aside. The fan plugs were super tight, the trick I used was a small falt screwdriver to push down on the release tab, then a larger flat screwdriver to lever the plug out of the fan unit....be careful with how much force you apply! If you need to remove the shroud altogether for some reason you will have to deal with all the plugs (tight) and clips (brittle)....good luck. I removed all of the clips and replaced them with cable ties that I will just cut next time. Also, in the Red Sport / 400R at least, the intake heat exchanger reservoir hose is bolted to the shroud in 2 places with 10mm headed bolts; so remove them (the hose stays in the car; no need to undo it at the t fittings down at the radiator lower mount. Once you've dealt with the HX hose and the wiring loom, there are 3x 10mm headed self tappers holding the top of the shroud to the radiator; remove those.   The shroud then lifts out of the bottom mounts where it sits on the radiator, up and onto the engine out of the way. Simples
    • Ok, disregard my “rate them” comment, sorry for my unrealistic input
×
×
  • Create New...