Jump to content
SAU Community

Recommended Posts

Hey, got this problem, I'm not getting full boost (18psi) in first gear, only getting 15psi. When I switch it to low boost (15psi) I only get around 12psi in first gear. I can hear the screamer pipe from around 9 psi on the high boost setting.

The wastegate spring is 1 Bar, Ive pressurized the intercooler piping up to 24psi and there are no leaks.

I can't remember if it was like this when I got the car tuned as I don't really drive the car.

Mods:

RB25DET Neo

GTX3071R

Link G4

50mm Turbosmart wastegate

6Boost low mount twinscroll Manifold

Edited by jhjones

 You know that 1 bar is only 14.5psi?  Have you got a boost controller or is boost controlled by the Link via a Mac Valve? I'm not sure that full boost in 1st gear is all that important. 

I'd be worried if you can hear the wastegate venting at 9 PSI.  Seems to indicate it's bleeding off too early.

You need to get one of these-

handpump.jpg

Remove the wastegate from the manifold (so you can see when it starts to open) and then disconnect the vacuum/pressure hose at the engine (so you're including all hose between engine and wastegate which may identify a leak somewhere) and then apply pressure (not vacuum) to the wastegate actuator.  In theory it should not crack open AT ALL until you reach what is supposed to be the wastegate spring pressure.  If it's opening before the target pressure then you either have a weak spring, a leaky diaphragm or a leak in the vacuum/pressure hose.  That's my evaluation anyway!!

Good luck.

 

Boost control is done by the link using a mac valve.

If there was a leaky diaphragm wouldn't i hear it leaking out the port on the mac valve when i pressurized the intercooler pipping. Same with a leak in the vacuum/pressure hose except i would hear it leaking from the hose.

In the high gears boost shoots up the 15psi then slowly creeps to 18psi. Normal?

Right, bigger turbo and getting full boost in 1st gear doesn't come along because of inertia of the CHRA and available energy on the turbine wheel.

I wouldn't be too worried about getting full boost in 1st gear but more by your creeping issue. What size your gate is ? Which manifold do you use ?

How old is your wastegate, and does it hit the track often? 

The wastegate springs get weak over time with continued heat cycling, i had 1 bar gate springs that ended up opening around 6psi due to the heat. This was after a couple of years on the track however.

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • As strange as this sounds (as they are fixed back), my Bride Xero CS seats are the most comfortable seats I've used.  I vote go genuine.  The only downside I've found is on very long drives, you can't reposition your body while driving. So even though its comfy, being locked in the same position eventually becomes uncomfortable. I find myself stopping every 3 or so hours to stretch my legs on long drives. 
    • You don't have to be bored driving a Camry. Not based on the way that a couple of f**king Ubereats/Didi/othersortofmethaddlednightshiftattheservicestationrecentimmmigrants were piloting them on the way to work this morning. f**k me dead!
    • FWIW, the Bride reps are really nice to sit in. The only complaint I have, other than the tear in my bolster, is that the velcro used to hold the backrest cushion in place, up under the headrest, is a little obvious and intrusive and could probably be done better. I don't know if that is a "feature" on the genuine ones also though. I haven't looked at a genuine one like the ones I have, only some of the older models. The other thing is, even though I bought the CF ones, I think the CF is really just decorative, over the top of the same FG as the normal seats. And so they really aren't light. Between the solidly built CF/FG seat, the steel frame in the recliner mechanism, and the solid-arse seat rail, they are probably heavier than even the stock seat. They are a serious lift to get in and out of the car.
    • Yes, and so the barest minimum power target is the one that makes the most sense. Massive power is fun, but you can only use it for 1.5s at a time, and only every now and then. Medium power levels allow you to enjoy the car far more often and for longer. 500 engine HP is just below 300 rwkW which is about the maximum that is sensible for any street car really. And for a 2.6L six, it will still leave you with a decent boost response and some sort of linearity of power delivery. As you get up towards 400rwkW the onset of power tends to be increasingly like a cliff and you need drag radials to keep the ground in proper contact with the car, and.... it's just not a car for driving around any more.
    • I already reached that conclusion myself after reading up a whole bunch and watching various videos from multiple sources. Don't know yet how I'd best manage that with the least amount of headache. Probably pulling the sump and just welding on a AN10 adapter or something. I also think it's healthy to take most opinions with a grain of salt, because experiences differ wildly and especially Aussies - when talking about RBs - don't know a world below 600whp drag builds. Personally I doubt I will ever take my R33 racing, so it's going to be a street car with the occasional spirited drive. Hence why I am (so far) under the impression that I'm going to be fine with a stock-ish engine for a while.
×
×
  • Create New...