Jump to content
SAU Community

Recommended Posts

Well if anyone remebers from my last post I got a new PFC and it wasn't working for me. So I sent it back to Japan only to find I was missing a power feed in my ECU connectors.

Now I got it back today and hooked it up. Car fired up with the check engine light illuminated. I went to the setup menu and turned off the boost controllers option. First thing I noticed is the idle was funny. It sounds like a miss but after monitering the Ing timming I see it goes from 18-20 BTDC and drops to 3-9 BTDC. It's like the ECU is retarding timing maybee to get the idle down? I did adjust the idle screw up to keep the car from stalling when it comes down from a high rev. Maybe the idle control valve is shut all the way but the ECU is trying to get the idle down by retarding the timing?

Also what kinda timing do I want to see under boost? When crusing around I see 30-38 BTDC. I haven't gotten on the car much yet for I want to get it to a dyno ASAP. I also find that when crusing under light throttle the throttle feels like an on/off switch and if I get it just right the car will bog off and on. Should I look at My TPS voltage? What should it be at closed throttle?

Where can I find a manuel in English?

Link to comment
https://www.sau.com.au/forums/topic/47218-new-power-fc-installed/
Share on other sites

Well if anyone remebers from my last post I got a new PFC and it wasn't working for me. So I sent it back to Japan only to find I was missing a power feed in my ECU connectors.

Now I got it back today and hooked it up. Car fired up with the check engine light illuminated. I went to the setup menu and turned off the boost controllers option. First thing I noticed is the idle was funny. It sounds like a miss but after monitering the Ing timming I see it goes from 18-20 BTDC and drops to 3-9 BTDC. It's like the ECU is retarding timing maybee to get the idle down? I did adjust the idle screw up to keep the car from stalling when it comes down from a high rev. Maybe the idle control valve is shut all the way but the ECU is trying to get the idle down by retarding the timing?  

Also what kinda timing do I want to see under boost? When crusing around I see 30-38 BTDC. I haven't gotten on the car much yet for I want to get it to a dyno ASAP. I also find that when crusing under light throttle the throttle feels like an on/off switch and if I get it just right the car will bog off and on. Should I look at My TPS voltage? What should it be at closed throttle?

Where can I find a manuel in English?

Hi, try

www.apexi-usa.com

30 degrees is OK in some conditions, but 38 is not. Monitor the knock levels on the Commander, that will tell you if there is too much timing. The Power FC takes some time to "learn" the engine characteristics. Lastly don't drive it too hard with the "out of the box" tuning, get it onto a dyno and, if you do nothing else, check the A/F ratios.

Hope that helps :)

Just for a bit of info ...

We were having idly and low rpm problems associated with our stock ECU a while ago.... Took it to autotech and they diagnosed it as missing a power feed or two. I believe there are meant to be 4 total, ours had 2? We had half what was required anyway. All the problems were fixed up when they repaired this.

I dont know how relevant this is, what with our problems being pre-existing and on a stock ECU, but anyway.

Idle right now is better. I set the idle to 1100 and it holds it steady. It will still shut off if you let the revs drop to quick but it did the same with the stock ECU.

Now the weird crusing problem is pretty bad. It's very hard to go down the highway at a constant speed. The car surges on/off a bit. It's not sudden but very noticalbe to me. I don't think my passangers can tell but with my foot on the throttle at a constant speed the car will feel like the brakes are being lightly applied and then released. It's the feels the worst around 3000 RPM's which is highway speed in 5th gear. One idea I have is it may have somthing to do with going between open/closed loop. Is there anything on the PFC to control it or moniter it.

My timing maps where as high as 42 BTDC. I set them back to 30 degrees for now. With the knock moniters on I didn't get much of a reading. But I turned the timing back just to be safe. The A/F's look good. 11.5:1 and richer under boost.

Idle right now is better. I set the idle to 1100 and it holds it steady. It will still shut off if you let the revs drop to quick but it did the same with the stock ECU.  

Now the weird crusing problem is pretty bad. It's very hard to go down the highway at a constant speed. The car surges on/off a bit. It's not sudden but very noticalbe to me. I don't think my passangers can tell but with my foot on the throttle at a constant speed the car will feel like the brakes are being lightly applied and then released. It's the feels the worst around 3000 RPM's which is highway speed in 5th gear. One idea I have is it may have somthing to do with going between open/closed loop. Is there anything on the PFC to control it or moniter it.

My timing maps where as high as 42 BTDC. I set them back to 30 degrees for now. With the knock moniters on I didn't get much of a reading. But I turned the timing back just to be safe. The A/F's look good. 11.5:1 and richer under boost.

I don't know enough about your mods to comment too much, other than 3,000rpm is where you get a boost ramp up. It is past the normal point of swap from closed loop to open. RB's are very sensitive to A/F ratios and ignition timing at that time. It is easy to pick on the dyno with part throttle loadings, spend a little time and you can easily tune it out.

Hope that helps :)

Well My setup doesn't make full boost till after 4,000 RPM's. I am running a 56 Trim T3/T4 with a stage 5 exhaust wheel .63 housing. So at 3K there isn't any boost. What kinda A/F's should I target while crusing? Right now it's 14.2-15.1 and it goes back and fourth.

As for the manuel Apexi-USA doesn't have a manuel to navitgate the Comander menu. It just shows how to hook it up.

Well My setup doesn't make full boost till after 4,000 RPM's. I am running a 56 Trim T3/T4 with a stage 5 exhaust wheel .63 housing. So at 3K there isn't any boost. What kinda A/F's should I target while crusing? Right now it's 14.2-15.1 and it goes back and fourth.

As for the manuel Apexi-USA doesn't have a manuel to navitgate the Comander menu. It just shows how to hook it up.

PM me your email address and I will email it to you, it is in Acrobat format. :)

Is your turbo plain bearing or ball bearing?

You got PM

I was out doing some test pulls at lunch. First thing I checked was my A/F ratio. It was nice and rich compaired to the stock ECU. With the stock ECU I was seeing 11.5-11.1. Now with the PFC in place I see 10.8-10.5 So I got plenty of fuel. I also saw that the knock wasn't going above 13 on the PFC display. So I layed into it in 3rd gear till about 7K. Knock was still below 13 and car felt pretty strong. Injector pulse max was 85.8% with my A/F ratio in the mid 10's. I did another pull and looked at the moniter. It showed knock at 83!! I guess the stock SMIC must be getting heat soaked or my timing is a little bit advanced? I am only running 10 PSI BTW.

So could somone explain the #'s for the injectors on the map? I assume lowering the # will lower the amount of fuel in that cell. Sorry for all the questions it's just being in the US there isn't anyone here who would have a clue of how to tune this setup. But I do have my own resources as to tuning myself (Wideband, Ears, and a good friend to ride with me to moniter things)

I still haven't taken care of the weird surging problem at cruising. My TPS voltage is constant, Air flow isn't jumping. The only thing I can say that is wierd is the A/F goes from 13.8:1-16:1 while crusing which I think it a bit much. I think with the Stock ECU it was going from 14:1-15:1. I don't know how I can adjust that though since it's in closed loop. Any ideas?

PM me your email address and I will email it to you, it is in Acrobat format. :(

Hi SK

sorry to be presumptuous, but if you have instructions for the commander could you please also email them to me as I have absolutely no idea. Thanks mate

Regards Alan

[email protected]

I still haven't taken care of the weird surging problem at cruising. My TPS voltage is constant, Air flow isn't jumping. The only thing I can say that is wierd is the A/F goes from 13.8:1-16:1 while crusing which I think it a bit much. I think with the Stock ECU it was going from 14:1-15:1. I don't know how I can adjust that though since it's in closed loop. Any ideas?

It's not closed loop, put the Commander in Monitor mode and note the map location. Then adjust (Setings) that point on the map. Simple. :rofl:

What is the F/B control O2 in the function menu? When I turn it off the car doesn't surge as much but it won't idle at all. Also what does the little Jappens writing mean next to the different functions? Is it on/off? I know when I first started the car the check engine light was on and when I went in and turned the Boost option to what I think is off then the light went out. I left the other things alone (Knock, injector warening) But funny thing is I have never seen the knock turn on the check engine light. At what point is that supose to happen?

BlueRB240: I am using 94 Oct fuel. Gotta love living in PA.

closed loop for O2, the characters are on/off - if you dont have the boost control fitted, then you would have to turn it off for the engine to work.

the car should idle with the O2 feedback on or off. You should turn the O2 feedback off for tuning. the O2 sensor could need replacing.

previous question, the TPS should read around 0.48 - o.5v closed. 0.4 to 0.6 indicates throttle shut. The AAC valve, I found, works best when left as open as possible, until the idle starts going above where you have it set. You should be able to get a good idle below 1100rpm, mine is fine with 256/264 cams at 900rpm, and there are people around running larger than that and still getting a good idle.

the adjustments in the fuel map are correction to the base power fc fuel map, so as you guessed raising the number means more fuel. To adjust the base map you need the power excel software only available throught Apexi authorised dealers

I think that just about covers the questions.

Ya that covers most questions I have soo far. Thanks

Now as for the stalling problem when the engine revs down. I have an HKS SSQ BOV on the car and ever since I put my larger turbo on it stalls. I can't get the BOV back into the intake because I made my own intake and my external wastegate gets in the way of the recirculation pipe.

Ok I turned off the F/B control and the car feels much better at crusing. I guess there isn't any way to control what the ECU does in Closed Loop mode? The O2 sensor seems to be working properly. The voltage goes up and down like it should while driving in closed loop.

I changed my O2 sensor, and the car was alot smoother at cruise. Voltage was doing what it was supposed to, but what made me suspect was that the voltage came down during cold start, to 0.02-0.00V. Once I fitted the new sensor, the voltage stayed at around 0.92-1.00V during cold start - so the old one was obviously knackered.

It will make a difference to economy, as the car goes into closed loop at idle and cruise - if you arent worried about that, then not much point in changing it I guess.

Another thing I found with a bigger turbo, is that reversion out of the AFM was greater - probably due to a larger inducer and more air flow, but anyway, I fixed that by replacing the mesh on the AFM. If you have both meshes, another thing to try would be perhaps to tension up the BOV a little.

Also, not sure where you have fuel cut recovery rpm set, but mine is 1200 and 1250 - might make a difference.

good luck.

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • First up, I wouldn't use PID straight up for boost control. There's also other control techniques that can be implemented. And as I said, and you keep missing the point. It's not the ONE thing, it's the wrapping it up together with everything else in the one system that starts to unravel the problem. It's why there are people who can work in a certain field as a generalist, IE a IT person, and then there are specialists. IE, an SQL database specialist. Sure the IT person can build and run a database, and it'll work, however theyll likely never be as good as a specialist.   So, as said, it's not as simple as you're thinking. And yes, there's a limit to the number of everything's in MCUs, and they run out far to freaking fast when you're designing a complex system, which means you have to make compromises. Add to that, you'll have a limited team working on it, so fixing / tweaking some features means some features are a higher priority than others. Add to that, someone might fix a problem around a certain unrelated feature, and that change due to other complexities in the system design, can now cause a new, unforseen bug in something else.   The whole thing is, as said, sometimes split systems can work as good, and if not better. Plus when there's no need to spend $4k on an all in one solution, to meet the needs of a $200 system, maybe don't just spout off things others have said / you've read. There's a lot of misinformation on the internet, including in translated service manuals, and data sheets. Going and doing, so that you know, is better than stating something you read. Stating something that has been read, is about as useful as an engineering graduate, as all they know is what they've read. And trust me, nearly every engineering graduate is useless in the real world. And add to that, if you don't know this stuff, and just have an opinion, maybe accept what people with experience are telling you as information, and don't keep reciting the exact same thing over and over in response.
    • How complicated is PID boost control? To me it really doesn't seem that difficult. I'm not disputing the core assertion (specialization can be better than general purpose solutions), I'm just saying we're 30+ years removed from the days when transistor budgets were in the thousands and we had to hem and haw about whether there's enough ECC DRAM or enough clock cycles or the interrupt handler can respond fast enough to handle another task. I really struggle to see how a Greddy Profec or an HKS EVC7 or whatever else is somehow a far superior solution to what you get in a Haltech Nexus/Elite ECU. I don't see OEMs spending time on dedicated boost control modules in any car I've ever touched. Is there value to separating out a motor controller or engine controller vs an infotainment module? Of course, those are two completely different tasks with highly divergent requirements. The reason why I cite data sheets, service manuals, etc is because as you have clearly suggested I don't know what I'm doing, can't learn how to do anything correctly, and have never actually done anything myself. So when I do offer advice to people I like to use sources that are not just based off of taking my word for it and can be independently verified by others so it's not just my misinterpretation of a primary source.
    • That's awesome, well done! Love all these older Datsun / Nissans so rare now
    • As I said, there's trade offs to jamming EVERYTHING in. Timing, resources etc, being the huge ones. Calling out the factory ECU has nothing to do with it, as it doesn't do any form of fancy boost control. It's all open loop boost control. You mention the Haltech Nexus, that's effectively two separate devices jammed into one box. What you quote about it, is proof for that. So now you've lost flexibility as a product too...   A product designed to do one thing really well, will always beat other products doing multiple things. Also, I wouldn't knock COTS stuff, you'd be surprised how many things are using it, that you're probably totally in love with As for the SpaceX comment that we're working directly with them, it's about the type of stuff we're doing. We're doing design work, and breaking world firsts. If you can't understand that I have real world hands on experience, including in very modern tech, and actually understand this stuff, then to avoid useless debates where you just won't accept fact and experience, from here on, it seems you'd be be happy I (and possibly anyone with knowledge really) not reply to your questions, or input, no matter how much help you could be given to help you, or let you learn. It seems you're happy reading your data sheets, factory service manuals, and only want people to reinforce your thoughts and points of view. 
    • I don't really understand because clearly it's possible. The factory ECU is running on like a 4 MHz 16-bit processor. Modern GDI ECUs have like 200 MHz superscalar cores with floating point units too. The Haltech Nexus has two 240 MHz CPU cores. The Elite 2500 is a single 80 MHz core. Surely 20x the compute means adding some PID boost control logic isn't that complicated. I'm not saying clock speed is everything, but the requirements to add boost control to a port injection 6 cylinder ECU are really not that difficult. More I/O, more interrupt handlers, more working memory, etc isn't that crazy to figure out. SpaceX if anything shows just how far you can get arguably doing things the "wrong" way, ie x86 COTS running C++ on Linux. That is about as far away from the "correct" architecture as it gets for a real time system, but it works anyways. 
×
×
  • Create New...